How to Replace the Front Motor Mount on a Mercury Villager
Motor mount failures seem to be a common problem for Mercury Villager vans. The same vehicle is also sold as the Nissan Quest.
The front mount is the most common one to fail. This mount takes most of the load when starting off from a stop. Repeated failures have been reported by some. Make sure you buy a replacement part that is form a quality manufacturer and has a lifetime warranty.
Raise the vehicle and support it safely. Remove the plastic splash guard by removing the fasteners that have 10mm heads. They also have Phillips screwdriver slots but will likely be too tight to easily remove with a screw driver.
Remove the oil filter. Support the engine using a jack under the oil pan. Raise it to the approximate position it will be in once the new mount is in place. It will likely have dropped down some if the front mount has failed.
Remove the two bolts that hold the mount to the cradle under the engine. Next, remove the bolt that goes through the center of the motor mount. Keep track of where each of the bolts came from. They all have 17mm heads but are different lengths.
Tilt the mount forward and then twist it out. If it will not tilt forward, raise the engine a bit more to make room. You may have to unclip the wiring harness that is fastened to the cross member to make room, but I was able to get it out with it in place.
Pull the mount out through the opening created by removing the oil filter. Insert the new mount through the same opening and tilt it back in to place.
Replace the center bolt through the bushing first. Put the nut on but do not tighten it all the way. Align the other two holes by raising or lowering he engine on the jack. Replace the two bolts through the cradle and tighten them down. Now finish tightening the center bolt in the bushing.
Clean the mounting surface of the oil filter and replace the oil filter. Replace the plastic cover. Lower the van and test it out. Check for leaks at the oil filter.
 |
99-02 Mercury Villager Nissan Quest Radio Cassette XF5F-18C870-AD * US $4.99 (0 Bid) Auction Ends: Tuesday Feb-07-2012 6:14:31 PST | Watch this Item |
 |
Nissan Quest/ Mercury Villager 1993 to 1995 GTS Headlight Covers US $29.99 Auction Ends: Tuesday Feb-07-2012 6:38:58 PST | Watch this Item |
 |
MERCURY VILLAGER NISSAN QUEST POWER WINDOW SWITCH US $16.99 Auction Ends: Tuesday Feb-07-2012 7:16:03 PST | Watch this Item |
 |
2 OUTER TIE ROD ENDS MERCURY NISSAN QUEST VILLAGER US $24.83 Auction Ends: Tuesday Feb-07-2012 7:26:23 PST | Watch this Item |
 |
1994-1998 Nissan Quest Mercury Villager Oxygen Sensor US $55.98 Auction Ends: Tuesday Feb-07-2012 7:36:03 PST | Watch this Item |
 |
New Aftermarket Radiator 99 00 01 02 Mercury Villager & Nissan Quest US $91.95 Auction Ends: Tuesday Feb-07-2012 7:42:35 PST | Watch this Item |
 |
MERCURY VILLAGER NISSAN QUEST 3.0 OIL PUMP 601-2082 US $145.00 Auction Ends: Tuesday Feb-07-2012 8:04:50 PST | Watch this Item |
 |
MERCURY VILLAGER NISSAN QUEST 3.0 OIL PUMP 601-2081 US $142.00 Auction Ends: Tuesday Feb-07-2012 8:21:52 PST | Watch this Item |
 |
NISSAN QUEST MERCURY VILLAGER 1999-2000-2001-2002 GRAY AIRBAG RIGHT PASSENGER US $29.00 Auction Ends: Tuesday Feb-07-2012 10:19:17 PST | Watch this Item |
 |
NEW OEM DASH WIRING HARNESS CLUSTER WIRE VILLAGER QUEST 94 95 MERCURY NISSAN NOS US $50.00 Auction Ends: Tuesday Feb-07-2012 10:30:34 PST | Watch this Item |
